Product ID:MT TONER (P-P), RP603Z
MSDS Date:11/01/1994
FSC:6850
NIIN:00N070613
MSDS Number: CBMFT

MINOLTA CORP

101 WILLIAMS DR
RAMSEY, NJ 07446
US

Emergency Phone: 201-825-4000

Info Phone: 201-825-4000

Cage: GO339

MINOLTA CORPORATION

RAMSEY, NJ 07446 US

Telephone: 201-825-4000

Cage: 23736

STYRENE ACRYLATE COPOLYMER

CAS: 25153-46-2

Fraction By Weight: >80%

OSHA PEL N/K

ACGIH TLV: N/K

CARBON BLACK

CAS: 1333-86-4

RTECS: FF5800000

Fraction By Weight: 5-10%

OSHA PEL 3.5 MG/M3

ACGIH TLV: 3.5 MG/M3

ORGANIC PIGMENT

CAS: 32517-36-5

Fraction By Weight: 1-5%

OSHA PEL N/K

ACGIH TLV: N/K

PROPENE POLYMERS; (POLYPROPYLENE)

CAS: 9003-07-0

RTECS: TR5000000

Fraction By Weight: 1-5%

OSHA PEL N/K

ACGIH TLV: N/K

SILICA, FUMED.

CAS: 7631-86-9

Fraction By Weight: <1%

OSHA PEL N/K

ACGIH TLV: N/K

LD50 LC50 Mixture:LD50:(ORAL,RAT) >5.0 G/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE:MINIMAL RESPIRATORY TRACT
IRRITATION MAY OCCUR AS WITH EXPOSURE TO LARGE AMOUNTS OF ANY
NONTOXIC DUST. MAY CAUSE COUGH AND RAISE PHLEGM. TONER PRESENTS LOW
HAZ FOR USUAL OCCUP SETTINGS. BASED ON AVAIL DATA, HUMAN EXPOS TO
TONER HAS BEEN SHOWN TO CAUSE MINIMAL RESP TRACT IRRIT AS MAY OCCUR
W/LG (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:AMTS OF ANY NON-TOX DUSTS. RSLTS OF
ONE ANIMAL STUDY WHERE RATS INHALED TONER THAT WAS 10 TIMES MORE
RESPIRABLE THAN COMMERCIALLY AVAIL TONER WERE OBSERVED TO HAVE NO
LUNG CHANGES @ LOW EXPOS (MOST RELEVANT LEV TO POTNTL HUMAN
EXPOS). AT HIGHER LEVS SLIGHT DEGREE OF LUNG FIBROSIS WAS OBSERVED
DUE TO (SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:INHAL:WASH NOSTRILS, RINSE MOUTH. INGEST:DILUTE STOM CONTENTS
W/SEVERAL GLASSES OF WATER. EYES:FLUSH WITH WATER FOR AT LEAST 15
MINUTES. SKIN:WASH WITH SOAP AND WATER.

Extinguishing Media:WATER, FOAM, DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . AVOID INHALATION OF SMOKE.
Unusual Fire/Explosion Hazard:IF DISPERSED IN AIR, TONER, LIKE MOST
FINELY DIVIDED ORGANIC POWDERS, MAY FORM AN EXPLOSIVE MIXTURE.

Spill Release Procedures:IF SPILLED, SWEEP UP OR VACUUM.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:NONE.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.

Respiratory Protection:NONE REQUIRED WHEN USED AS INTENDED IN MFR
EQUIPMENT. NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE
OF CONCERN .
Ventilation:NOT APPLICABLE.
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGLES .
Other Protective Equipment:ANSI APPRVD EMERGENCY EYE WASH & DELUGE
SHOWER .
Work Hygienic Practices:NONE.
Supplemental Safety and Health
EFTS OF OVEREXP:EXCESS AMTS OF DUST RETAINED IN LUNGS FOR PRLNGD
INTERVAL. ORAL LD50:>5.0G/KG (RATS). DERM LD50:>2.0G/KG (RATS).
INHAL LD50:>0.4MG/L(RATS) FOR 4-HRS. (THIS WAS HIGHEST ATTAINABLE
CONC. THERE WERE NO DEATHS DURING STUDY).

Spec Gravity:1.15 (H*2O=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BLACK POWDER, FAINT ODOR.

Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:PRODUCTS OF COMBUSTION ARE TOXIC.
AVOID BREATHING OF SMOKE.

Waste Disposal Methods:WASTE MAY BE DISPOSED OR INCINERATED UNDER
CONDITIONS WHICH MEET ALL FEDERAL, STATE AND LOCAL ENVIRONMENTAL
REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.